Back to all

Tuffy Jacksonville Service for Your Exhaust System

July 2, 2020

Your vehicle's exhaust system is more than just a tailpipe and a muffler. In fact, it is one of the most complex systems on your vehicle.

drive

The manifold is attached to the vehicle engine. It collects exhaust from the cylinders and directs it into the exhaust pipe. Gaskets seal the connection of the manifold to the engine and to other joints. A cracked or loose manifold or a leaking or damaged gasket can allow dangerous gases to enter the passenger compartment of a vehicle. One of these gases is carbon monoxide, which is colorless, odorless and deadly. For this reason, it is important Jacksonville residents keep their exhaust system in good repair.


The pipes that connect the various parts of the exhaust system can rust or be damaged by rocks or other road debris. Such damage can cause dangerous gases to leak into the air.

The catalytic converter is the next component of your vehicle exhaust system. It sort of looks like a muffler. Its job is to change dangerous gases into harmless carbon dioxide and water. The catalytic converter doesn't require any regular maintenance, but it can wear out. If it fails, you will need a new catalytic converter to pass an emissions test in Florida. Call Tuffy Jacksonville at 904-992-4176 if you suspect a problem with your catalytic converter.

Oxygen sensors in the exhaust pipe monitor the oxygen content of the exhaust. This helps the vehicle engine's computer keep the fuel-to-air mixture at optimal levels.

The muffler is also part of your vehicle exhaust system, but it deals with a different kind of emission. It keeps your vehicle from emitting bad sounds. Mufflers act like finely tuned musical instruments. They create a feedback of sound waves to absorb or decrease the noises made by your engine. Different mufflers can create different sound waves, so you can actually “tune” your car to produce a particular sound, anything from whisper to rumble.

It is important that damaged mufflers be replaced immediately at your Jacksonville automotive service center, especially if they are leaking. Not only will the extra noise annoy your Jacksonville neighbors, a leaky muffler could be serious.

The entire exhaust system is attached to your vehicle by hangers and clamps. These fasteners can rust, come loose or break. The components of the exhaust system can get very hot, so when the hangers or clamps fail, these hot components can come into contact with other parts such as wires and hoses. These can melt, causing serious and damage to your vehicle. Good car care requires that you have your exhaust system inspected regularly.

Caring for your vehicle exhaust system at Tuffy Jacksonville yields cosmetic benefits like quieting your engine sounds, but also may impact your health and safety. Your life, or the life of a loved one, may actually be on the line.

Tuffy Jacksonville
14026 Beach Blvd.
Jacksonville, Florida 32250
904-992-4176
http://www.tuffyonbeachblvd.com

 

More articles from Tuffy Jacksonville

Start Me Up (Ignition Systems)

December 5, 2021

When you start up your gasoline engine car, you may not know that it's using the same ignition principles as it has for decades. You have spark plugs that require enough power so a spark can jump across a gap at its tip. Years ago, a vehicle's 12-volt system had to produce 15,000-25,000 volts t... More

Give it the Boot (Ball Joint Boot Replacement)

November 28, 2021

Your vehicle may be wearing boots right now and you might not even know it. They're called ball joint boots. They're actually protective, flexible things that protect parts of your suspension (called ball joints) from all the hazards the road can fling at them. If one of those ball joint boots... More

Cold Weather Vehicle No-Nos (Items to Avoid Storing in a Freezing Vehicle)

November 21, 2021

It's always easier to leave a few things in your vehicle so you'll have them on hand. But in cold weather, while it's a good idea to carry items such as a phone charger, blanket and shovel, there are some things you shouldn't store in your vehicle. Medicines and drugs. Cold temperatures can af... More