Back to all

Jacksonville Drivers: Is It Time to Replace Your PCV Valve?

June 27, 2017

drive

The crankcase is the lower part of the engine where the crankshaft is housed and where the engine oil lives. The crankshaft is connected to the pistons that power the engine.


When you are diving around Jacksonville, fuel is burned in your vehicle engine, it pushes the pistons down and the crankshaft rotates and sends power to the transmission. Some of the explosive gases from combustion squeeze past the pistons and down into the crankcase.

Now this gas is about 70% unburned fuel. If it were allowed to remain in the crankcase, it would contaminate the oil and quickly turn it to sludge. Sludge is like Vaseline and clogs passages in the engine, leading to damage.

Also, the pressure build up would blow out seals and gaskets. So in the old days, there was just a hose that vented the crankcase out into the air. Obviously, not good for our air quality in Jacksonville, Florida.

Enter the PCV valve. It's a small, one-way valve that lets out the gases from the crankcase and routes them back into the air intake system where they are re-burned in the engine. Fresh air comes into the crankcase through a breather tube. This makes for good circulation in the crankcase. And that gets the air out. As you can imagine, however, the valve gets gummed up over time.

Your vehicle manufacturer usually recommends they be changed somewhere between 20,000 to 50,000 miles/30,000 to 80,000 kilometers. Unfortunately, PCV valve replacement is left out of some vehicle owner's manuals, but your friendly service advisor at Tuffy Jacksonville, we will make sure your PVC is replaced if needed.

Tuffy Jacksonville
14026 Beach Blvd.
Jacksonville, Florida 32250
904-992-4176
http://www.tuffyonbeachblvd.com

More articles from Tuffy Jacksonville

Start Me Up (Ignition Systems)

December 5, 2021

When you start up your gasoline engine car, you may not know that it's using the same ignition principles as it has for decades. You have spark plugs that require enough power so a spark can jump across a gap at its tip. Years ago, a vehicle's 12-volt system had to produce 15,000-25,000 volts t... More

Give it the Boot (Ball Joint Boot Replacement)

November 28, 2021

Your vehicle may be wearing boots right now and you might not even know it. They're called ball joint boots. They're actually protective, flexible things that protect parts of your suspension (called ball joints) from all the hazards the road can fling at them. If one of those ball joint boots... More

Cold Weather Vehicle No-Nos (Items to Avoid Storing in a Freezing Vehicle)

November 21, 2021

It's always easier to leave a few things in your vehicle so you'll have them on hand. But in cold weather, while it's a good idea to carry items such as a phone charger, blanket and shovel, there are some things you shouldn't store in your vehicle. Medicines and drugs. Cold temperatures can af... More